HUANG Weikang,HUANG Wenxin,CAO Li,et al.Optimum Design of Magnetic Circuit of Voice Coil Motor With Wireless Power Supply[J].MICROMOTORS,2020,53(06):6-12.
无线供电式音圈电机的磁路优化设计
- Title:
- Optimum Design of Magnetic Circuit of Voice Coil Motor With Wireless Power Supply
- Keywords:
- voice coil motor(VCM); wireless supply power; magnetic circuit optimization; air gap flux density; electromagnetic performance
- 分类号:
- TM359.4
- 文献标志码:
- A
- 摘要:
- 针对音圈电机在长时间往复运动容易发生故障的缺陷,提出一种取消供电引线,利用电磁感应原理进行非接触电能传输的新型音圈电机结构。本文对新型音圈电机的供电结构进行了数学模型推导分析,并且通过有限元优化分析软件对不同永磁体分布方式和结构尺寸参数下的气隙磁密进行分析,提出了相应的优化思路。最后完成对永磁体磁路结构和供电磁路结构的尺寸优化设计,令该新型结构可以满足设计要求并制作了一台样机验证了该优化结果
- Abstract:
- Aiming at the defect that voice coil motor is prone to failure in long-term reciprocating motion, a new voice coil motor structure is proposed, which cancels power supply lead and uses electromagnetic induction principle to transmit non-contact electric energy. In this paper, the mathematical model of the power supply structure of the new voice coil motor was deduced and analyzed, and the air gap flux density under different permanent magnet distribution and structure size parameters was analyzed by the finite element optimization analysis software, and the corresponding optimization ideas were put forward. Finally, the size optimization design of the permanent magnet magnetic circuit structure and the power supply electromagnetic circuit structure was completed, so that the new structure can meet the design requirements, and a prototype was made to verify the optimization results
参考文献/References:
[1] Huang Weikang,Cao Li,Huang Wenxin,et al.Research on Voice Coil Motor for a New Construction With Wireless Power Supply [C]. ICEMS 2019:1570545208.
[2]黄维康.电磁感应式供电的音圈电机:中国,21811581935.8[P].2018-11- 05.
[3]兴连国,周慧兴. 音圈电机研究及应用综述[J]. 微电机,2011(8):82-87.
[4]常雪峰,陈幼平,艾武,等. 音圈直线电动机设计、控制及应用综述[J]. 微电机,2008,41(11): 82- 87.
[5]蔡林,杨善水.直线力电动机性能分析[J]. 微特电机,2010(7):38- 46.
[6]孙雨施.关于永磁的计算模型[J].电子学报,1982(5):86-89.
[7]杨光.基于三维磁场计算的永磁音圈电机结构优化设计[D].天津:天津大学,2004.
[8]邹继斌,王骞. 音圈电机的电磁场计算与分析[J]. 微特电机,2008,36( 2): 4- 6.
[9]李景天,郑勤红,宋一得,等.用边界元法计算永磁体磁场[ J].电工电能新技术,1998(1):7-9.
[10]Campbell P,Chari M V K,Angeio J D. Three Dimension Finite Element Solution of Permanent Magnet Machines[J].IEEE Transaction on Magnetics, 1981,17(6):2997-2999.
[11]林德华,蔡从中,董万春.方型永磁体表面磁感应强度分布的研究[J].工科物理,1999,9(2):5- 9.
[12]Cao Yonghui,Wu Shuai,Jiao Zongxia. Design and Simulation of Voice Coil Motor for the Micro-electric Load Simulator[C].Proceedings of 2011 International Conference on Fluid Power and Mechatronics,2011: 930- 934.
备注/Memo
收稿日期:2019-10-30,修回日期:2020-03-27
作者简介:黄维康(1993),男,硕士,研究方向为无线供电式音圈电机的设计及控制。
通信作者:黄文新(1966),男,教授,博士生导师,研究方向为电机设计及控制。